Product ID:AEROSHELL FLUID 4 (MIL-H-5606A), 60421
MSDS Date:11/27/1994
FSC:9150
NIIN:00N093090
Status Code:A
MSDS Number: CJXFY

Emergency Phone: 713-473-9461

Info Phone: 713-241-4819

Preparer: J.C. WILLETT

Cage: 52527

Telephone: 800-231-6950

Cage: 52527

MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)

CAS: 64742-53-6

RTECS: PY8036001

ADDITIVES

LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HEALTH EFTS NOTED BELOW ARE CONSISTENT
W/REQS UNDER OSHA HAZARD COMMUNICATION STD (29 CFR 1910.1200). EYE
CONTACT: LUBRICATING OILS ARE GENERALLY CONSIDERED NO MORE THAN
MINIMALLY IRRIT TO EYES. SKIN CONTACT: LUBRICATING OILS ARE
GENERALLY CONSIDERED NO MORE THAN MILDLY IRRIT TO SKIN. PRLNGD/RPTD
CONTACT MAY LEAD TO VARIOUS SKIN DISORDERS SUCH AS DERM, OIL ACNE
OR FOLLICULITIS. RELEASE DURING HIGH USAGE MAY RSLT IN INJECTION
OF OIL INTO SKIN CAUSING LOCAL NECROSIS. LOCAL NECROSIS IS
EVIDENCED BY DELAYED ONSET OF PAIN & TISSUE DAMAGE A FEW HRS
FOLLOWING INJECTION. INHAL: INHAL OF VAPS (GENERATE D AT HIGH TEMPS
ONLY) (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZS: OR OIL MIST FROM THIS PROD MAY CAUSE
MILD IRRIT OF UPPER RESPIRATORY TRACT. INGEST: THIS MATL MAY BE
HARMFUL OR FATAL IF SWALLOWED. INGEST MAY RESULT IN VOMITING:
ASPIRTION (BREATHING) OF V OMITUS INTO LUNGS MUST BE AVOIDED AS
EVEN SMALL QUANTITIES MAY RSLT IN ASPIRATION PNEUMONITIS.
ASPIRATION PNEUMONITIS MAY BE EVIDENCED BY COUGHING, LABORED
BREATHING & CYANOSIS (BLUISH SKIN); IN SEVER E CASES DEATH MAY
OCCUR. OTHER HEATLH EFTS: THIS PROD & ITS COMPONENTS ARE NOT
CLASSIFIED AS CARCINS BY IARC, NTP OR OSHA. SUPPLEMENTAL HEALTH
INFO: NONE IDENTIFIED.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYE CONTACT: FLUSH W/WATER FOR AT LEAST 15 MIN WHILE HOLDING
EYELIDS OPEN. GET MED ATTN. SKIN CONTACT: IF MATL IS INJECTED UNDER
SKIN, GET MED ATTN PROMPTLY TO PREVENT SERIOUS INJURY. INHAL:
REMOVE VI CTIM TO FRESH AIR & PROVIDE OXYGEN IF BRTHG IS DFCLT. GET
MED ATTN. INGEST: DO NOT INDUCE VOMIT. IF VOMIT OCCURS SPONT, KEEP
HEAD BELOW HIPS TO PVNT ASPIR OF LIQ INTO LUNGS. GET MED ATTN. NOTE
TO MD: IF MORE THAN 2.0 ML PER KG HAS BEEN INGESTED & VOMIT HAS
NOT OCCURRED, EMESIS SHOULD BE INDUCED W/SUPERVISION. KEEP VICTIM'S
HEAD BELOW HIPS TO PVNT ASPIR. IF SYMPS SUCH AS LOSS OF GAG REFLEX,
CONVULS IONS OR UNCON (SUPDAT)

Flash Point Method:COC
Flash Point:=107.2C, 225.F
Lower Limits:N/AV
Upper Limits:N/AV
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO*2. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED ON SURFACE OF WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . MATERIAL WILL NOT BURN UNLESS PREHEATED. COOL FIRE
EXPOSED CONTAINERS WITH WATER.

Spill Release Procedures:MAY BURN ALTHOUGH NOT READILY IGNITABLE. USE
CAUTIOUS JUDGMENT WHEN CLEANING UP LG SPILLS. LG SPILLS: WEAR NIOSH
APPRVD RESP & PROT CLTHG AS APPROP. SHUT OFF SOURCE OF LEAK IF SAFE
TO DO SO. DIKE & CN TNR. REMOVE W/VACUUM TRUCKS OR PUMP TO STORAGE
SALVAGE VESSELS. SOAK UP RESIDUE W/ABSORB SUCH AS CLAY, SAND OR
OTHER SUITABLE MATLS. DISPOSE OF PROPERLY. FLUSH AREA W/WATER
(SUPDAT)

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH W/SOAP AND WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES, INCLUDING SHOES, THAT CANNOT BE
DECONTAMINATED.

Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS, USE A NIOSH APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. IN ACCORD WITH 29 CFR 1910.123 USE EITHER A NIOSH
APPROVED ATMOSPHERE-SUPPLYING RE SPIRATOR OR NIOSH APPROVED
AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS AND PARTICULATES.
Protective Gloves:CHEMICAL RESISTANT GLOVES; TEST DATA FROM PUBLISHED
LITERATURE &/OR (SUPDAT)
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR OTHER PROTECTIVE CLOTHING AS REQUIRED TO
MINIMIZE SKIN CONTACT.
Supplemental Safety and Health
FIRST AID PROC: OCCUR BEFORE EMESIS, GASTRIC LAVAGE USING A CUFFED
ENDOTRACHEAL TUBE SHOULD BE CONSIDERED. SPILL PROC: TO REMOVE TRACE
RESIDUE. SMALL SPILLS: TAKE UP W/ABSORB MATL & DISPOSE OF PROPERL
Y. PROT GLOVES: GLOVE & CLTHG MFRS INDICATE BEST PROTECTION IS
PROVIDED BY NITRILE GLOVES.

Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:=-59.4C, -75.F
M.P/F.P Text:POUR POINT
Vapor Pres:<0.1 MM HG
Spec Gravity:0.8692 (H*2O=1)
Viscosity:10 (CS @ 130F)
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED LIQUID; SLIGHT HYDROCARBON ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAMES.
Hazardous Decomposition Products:THERMAL DECOMP PRODS ARE HIGHLY
DEPENDENT ON COMBUST CNDTNS. A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQ, PARTICULATES & GASES WILL EVOLVE WHEN THIS MATL UNDERGOES
PYROLYSIS OR COMBUSTION. (OTHER INFO)

Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT WOULD NOT BE
A HAZARDOUS WASTE BY RCRA CRITERIA (40 CFR 261). PLACE IN AN
APPROPRIATE DISPOSAL FACILITY IN COMPLIANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Toxicological Information:ACUTE TOXICITY DATA - HYDROTREATED LIGHT
NAPHTHENIC DISTILLATE: ACUTE DERMAL LD50: >3.16 G/KG, RABBIT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THIS PROD IS COVERED BY EPA'S COMPREHENSIVE ENVIRONMENTAL
RESPONSE, COMPENSATION & LIABILITY ACT (CERCLA) PETRO EXCLUSION.
THEREFORE, RELS TO AIR, LAND OR WATER ARE NOT REPORTABLE UNDER
CERCLA ("SUPER FUND"). HOWEVER, UNDER SECTION 311 OF EPA'S CLEAN
WATER ACT (CWA), PROD IS CONSIDERED AN OIL. AS SUCH, SPILLS
INTO/LEADING TO SURF WATERS THAT CAUSE SHEEN MUST BE REPORTED TO
THE NRC, 800-424-8802. PR OD IS OIL UNDER 49 CFR (DOT) PART 130. IF
SHIPPED BY RAIL OR HIGHWAY IN TANK W/CAPACITY OF 3,500 GALS OR
MORE, IT IS SUBJECT TO REQS OF PART 130. MIX SOLNS IN WHICH THIS
PROD IS PRESENT AT 10% OR MORE MAY ALSO BE SUBJECT TO THIS RULE.

Transport Information:DEPARTMENT OF TRANSPORTATION CLASSIFICATION: NOT
HAZARDOUS BY DOT REGULATIONS.

SARA Title III Information:BASED ON THE DATA AVAILABLE TO SHELL, THIS
PRODUCT IS NOT REGULATED BY SARA, TITLE III. IN ACCORDANCE WITH
SARA TITLE III, SECTION 313, THE ATTACHED ENVIRONMENTAL DATA SHEET
(EDS) SHOULD ALWAYS BE COP IED AND SENT WITH THE MSDS.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES. PROTECTION
OF STRATOSPHERIC OZONE (PURSUANT TO SECTION 611 OF CLEAN AIR ACT
AMENDMENTS OF 1990): PER 40 CFR PART 82, THIS PRODUCT DOES NOT
CONTAIN NOR WAS IT DIRECTLY MANUFACTURED W/ANY CLASS I OR CLASS II
OZONE DEPELETING SUBSTANCES.
State Regulatory Information:THE FOLLOWING CHEMICALS ARE SPECIFICALLY
LISTED BY INDIVIDUAL STATES: OTHER PRODUCT SPECIFIC HEALTH AND
SAFETY DATA IN OTHER SECTIONS OF THE MSDS MAY ALSO BE APPLICABLE
FOR STATE REQUIREMENTS. FOR DET AILS ON YOUR REGULATORY
REQUIREMENTS YOU SHOULD CONTACT THE APPROPRIATE AGENCY IN YOUR
STATE. MASSACHUSETTS SUBST LIST: HYDROTREATED LIGHT NAPHTHENIC
DISTILLATE (CAS NO: 64742-53-6), 80-90%.